Hyundai Accent Manuals

Hyundai Accent: Water pump. Troubleshooting - Cooling System - Engine Mechanical SystemHyundai Accent: Water pump. Troubleshooting

Troubleshooting

Water Pump
Symptoms
Possible Causes
Remedy
Coolant leakage
•
From the bleed hole of the water pump
Visually check
•
Check leaks after about ten-minute warming up.
•
If coolant still leaks, replace a water pump.
•
If leakage stops, reuse the water pump (Do not replace the pump with a new one).
•
From gaskets or bolts
•
Check the tightening of the water pump mounting bolts.
•
Retighten the mounting bolts.
•
Check damage of gaskets or inflow of dust.
•
Replace the gasket and clean dust off.
•
From outer surface of water pump
•
Check the material or any cracks of the water pump.
•
Poor material. If any crack found, replace the water pump.
Noise
•
From bearings
•
From mechanical seals
•
Impeller interference
Inspection with a stethoscope
•
After starting the engine, check noise with a stethoscope.
•
If there is no noise, reuse the water pump(do not replace it).
•
If there is any noise from the water pump, remove the drive belt and recheck.
Inspection after removing a drive belt
•
After removing a water pump and a drive belt, check noise again.
•
If there is noise, reuse the water pump. Check other drive line parts.
•
If there is no noise, replace the water pump with a new one.
Inspection after removing a water pump
•
After removing a water pump and a drive belt, check noise again.
•
If there is any interference between them, replace the water pump with a new one.
Overheating
•
Damaged impeller
•
Loosened impeller
Loosened impeller
•
Corrosion of the impeller wing
•
Check engine coolant.
•
Poor coolant quality / Maintenance check
•
Impeller seperation from the shaft
•
Replace the water pump.


Inspection
1. Check each part for cracks, damage or wear, and replace the coolant pump assembly if necessary. 2. Check the bearing for damage, abnorma ...

Radiator. Components and Components Location
Components 1. Cooling fan & reservoir tank assembly 2. Radiator lower hose 3. Air guard 4. Upper cover 5. Radiator upper hose 6. Radiator mounting brack ...

See also:

Rear Body ( 5Door )
Side outer panel rear corner Tail gate hinge mounting hole (Ø14) Tail gate hinge mounting hole ...

Certification label
The certification label is located on the driver's door sill at the center pillar. This label shows the maximum allowable weight of the fully loaded vehicle. This is called the GVWR (Gross Ve ...

Inspection
1. Check the audio remote control switch (A) for resistance between terminals in each switch position. Switch C ...

Hyundai Accent Manuals


© 2011-2024 Copyright www.hamanual.com